Diagnosing Power Loss. A key symptom of Ford Transit 2.4 injector problems is a loss of power while driving. This can be accompanied by a decrease in fuel economy and an increase in emissions. If you notice any of these issues, it's important to take your vehicle to a mechanic as soon as possible for diagnosis and repair. Re: heaters not blowing hot air, cold air only. by wojciech » Fri Mar 25, 2022 12:40 pm. Check that the water pipes connected to the heater valne on the engine side are warm. Whether the valve is open or closed, fluid should always circulates through these tubes. If the wires going to the valve are warm, and from the valve to the heater are Step one, engine off, apply vacuum to the valve and see if the valve holds vacuum. If it does, the diaphragm is good. Next, look in the openings in the side of the valve for movement when vacuum is applied. If it is, the diaphragm in the valve is good, and the valve is free to move. The next step, engine still off, reconnect the vacuum line to Transit Van. 2015. As You're looking straight at the engine of Your 2015 Ford Transit, You'll see the exhaust gas temperature (EGR) sensor located on the left side of the intake manifold near the valve. To replace the sensor, You'll want to first disconnect the negative battery cable and set it aside, and then remove the electrical connector on There seems to be a problem completing the request at present. EGR VALVE & MANIFOLD FOR FORD TRANSIT CONNECT S-MAX GALAXY FOCUS MK2 1.8 TDCI (Fits: Ford S-Max 1. Check wiring at the exhaust loom multi-plugs for breaks. There were no obvious breaks which was a good sign. 2. I used a Multimeter to test, while the engine was running, that I was receiving 5V at each of the temp sensors multi-plugs. Posted August 4, 2015. blanking the EGR might help but the fact its cutting out sounds like a fuel / air problem rather than EGR. Check the air filter, and also check all pipes and hoses are not damaged. Next thing to do would be a leak off test to ensure there is fuel going through the injectors, 1. Quote. 541A EGR Valve Repair Set for Boxer Ducato Jumper Transit Land Rover TDCi JTDM. AU $12.71. + AU $7.41 postage. Check the item description to confirm this fits your vehicle. replace the EGR valve on this Peugeot Boxer vanit's fitted would a 2.2 HDI also known as a 2.2 TDCi in Ford Transitold part was stuck closed 582 posts · Joined 2019. #4 · Aug 15, 2021. The 1.8 TDCi is a Euro 4 engine. You can blank the EGR off on that without any problems (as I have) since it has no O2 sensors on the exhaust. It's all down to whether the PCM monitors O2 content in exhaust. If it does, then blanking the EGR will throw a code and put your EML light on, which, as has dFnHM.